基于微观方法对液态铝泡沫宏观析液过程的数值模拟研究

李科; 解茂昭; 刘红

doi:10.3879/j.issn.1000-0887.2009.12.006

基于微观方法对液态铝泡沫宏观析液过程的数值模拟研究

doi: 10.3879/j.issn.1000-0887.2009.12.006

李科^1,2,3,
解茂昭¹,
刘红¹

大连理工大学能源与动力学院,辽宁大连 116024;2.内蒙古科技大学能源与环境学院,内蒙古包头 014010;3.清华大学航天航空学院,北京 100084

基金项目: 国家自然科学基金资助项目(50876017)

详细信息

作者简介:
李科(1981- ),男,内蒙古鄂尔多斯人,副教授,博士(联系人.E-mail:like16615.student@sina.com);解茂昭(1944- ),男,成都人,教授,博士生导师(E-mail:xmz@dlut.edu.cn).

中图分类号: O368;TK121
计量
- 文章访问数: 1109
- HTML全文浏览量: 77
- PDF下载量: 743
- 被引次数: 0
出版历程
- 收稿日期: 2009-02-17
- 修回日期: 2009-11-11
- 刊出日期: 2009-12-15

Microscopical and Macroscopical Numerical Study on the Drainage Process in Fabricating Foamed Aluminum

School of Energy and Power Engineering, Dalian University of Technology, Dalian, Liaoning 116024, P. R. China;

摘要

摘要: 通过微元管内流动模型，研究了液态金属熔体泡沫体内单条Plateau边界内析液过程中的速度场．分析了不同Newton表面粘度，即不同的气液界面运动能力（无量纲参数M）下，Plateau边界内速度的分布．结果显示：在相同的气液界面运动能力和曲率半径条件下，泡沫体内固壁处Plateau边界内速度约是内部Plateau边界内速度的6～8倍，从而解释了不同容器内泡沫体析液速率的差异现象；发现M存在1个临界值，在此值的两边，液膜厚度与曲率半径的比值对Plateau边界内速度的影响呈现出相反的趋势．结合多尺度方法，进而利用微观计算结果建立了泡沫体的整体宏观析液模型，将模型计算结果和经典析液方程计算结果及实验值作了比较，结果表明：该文模型计算结果与实验值在泡沫层上部、中部吻合较好，M值和气泡大小对析液过程有显著影响．
- 泡沫铝 /
- 析液 /
- Plateau边界 /
- 含液率 /
- 五边形十二面体
Abstract: Velocity field in a single plateau border of aluminum foam during drainage process was studied by a mathematic model for the flow inside a micro-channel.It is shown that the liquid/gas interface mobility,which is characterized by the Newtonian surface viscosity,has substantial effect on velocity inside single plateau border.It's found that at the same liquid/gas interfacial mobility (M)and same radius of curvature,the max velocity inside an exterior plateau border is about 6~8 times as large as that inside an interior plateau border.It's also found that a critical value of the interfacial mobility in interior plateau border,for values greater or less than which the effects of the film thickness on the velocity in plateau border show opposite tendencies.Based on the results from the microscopical model,a new macroscopical drainage model was presented for aluminum foams.Comparisons of computed results by this model with experimental data from the literature and with those from the classical drainage equation show a reasonable agreement.Furthermore,computational results reveal that the liquid holdup of foams is dependent strongly on the value of M and bubble radius.
- foamed aluminum /
- drainage /
- Plateau border /
- liquid holdup /
- pentagonal dodecahedron

HTML全文

参考文献(24)

[1]	Lehmhus D,Banhart J,Rodriguez-Perez M A.Adaptation of aluminium foam properties by means of precipitation hardening[J].Materials Science and Technology,2002,18(5):474-479. doi: 10.1179/026708302225002182
[2]	Lehmhus D,Banhart J.Properties of heat-treated aluminum foams[J].Materials Science and Engineering A,2003,349(2):98-110. doi: 10.1016/S0921-5093(02)00582-8
[3]	Paul E C,Kevin D C.Design of experiments for thermal characterization of metallic foam[J].Journal of Thermophysics and Heat Transfer,2005,19(3):367-374. doi: 10.2514/1.6725
[4]	Gergely V,Clyne T W.Drainage in standing liquid metal foams:modeling and experimental observations[J].Acta Material,2004,52(10):3047-3058. doi: 10.1016/j.actamat.2004.03.007
[5]	Cox S J,Weair D,Hutzler S,et al.Applications and generalizations of the foam drainage equation[J].The Royal Society,2000,456（2002）:2441-2464. doi: 10.1098/rspa.2000.0620
[6]	Koehler S A,Hilgenfeldt S,Stone H A.A generalized view of foam drainage:experiment and theory[J].Langmuir,2000,16(15):6327-6341. doi: 10.1021/la9913147
[7]	Durand M,Langevin D.Physicochemical approach to the theory of foam drainage[J].Eur Phys J E:Soft Matter and Biological Physics,2002,7(1):35-41. doi: 10.1007/s10189-002-8215-0
[8]	Hutzler S,Cox S J,Wang G.Foam drainage in two dimensions[J].Colloids and Surfaces A:Physicochem Eng Aspects,2005,263(3):178-183. doi: 10.1016/j.colsurfa.2005.02.001
[9]	Grassia P,Neethling S J,Cervantes C,et al.The growth,drainage and bursting of foams[J].Colloids and Surfaces A:Physicochem Eng Aspects,2006,274(3):110-124. doi: 10.1016/j.colsurfa.2005.08.040
[10]	Leonard R A,Lemlich R.A study of interstitial liquid flow in foam[J].AIChE J,1965,11(1):18-24. doi: 10.1002/aic.690110108
[11]	Nguyen A V.Liquid drainage in single Plateau borders of foam[J].J Colloid Interface Sci,2002,249(1):194-199. doi: 10.1006/jcis.2001.8176
[12]	Koehler S A,Hilgenfeldt S,Stone H A.Foam drainage on the micro scale Ⅰ:modeling flow through single Plateau borders[J].Journal of Colloid and Interface Science,2004,276(2):439-449. doi: 10.1016/j.jcis.2003.12.060
[13]	Koehler S A,Hilgenfeldt S,Stone H A.Foam drainage on the micro scale Ⅱ:imaging flow through single Plateau borders[J].Journal of Colloid and Interface Science,2004,276(2):420-438. doi: 10.1016/j.jcis.2003.12.061
[14]	Li J,Zhang J,Ge W,et al.Multi-scale methodology for complex systems[J].Chemical Engineering Science,2004,59(8):1687-1700. doi: 10.1016/j.ces.2004.01.025
[15]	Stephan A K,Hilgenfeldt S,Eric R W,et al.Drainage of single Plateau borders:direct observation of rigid and mobile interfaces[J].Physical Review E,2000,66(4):040601-1-4.
[16]	Magrabi S A,Dlugogorski B Z,Jameson G J.A comparative study of drainage characteristics in AFFF and FFFP compressed-air fire-fighting foams[J].Fire Safety Journal,2002,37(1)：21-52. doi: 10.1016/S0379-7112(01)00024-8
[17]	WANG Ze-bin,Narsimhan G.Model for Plateau border drainage of power-law fluid with mobile interface and its application to foam drainage[J].Journal of Colloid and Interface Science,2006,300(1),327-337.
[18]	Stone H A,Koehler S A,Hilgenfeldt S,et al.Perspectives on foam drainage and the influence of interfacial rheology[J].Journal of Physics:Condensed Matter,2003,15(1):S283-S290.
[19]	Saint-Jalmesa A,Zhang Y,Langevin D.Quantitative description of foam drainage:transitions with surface mobility[J].The European Physical Journal E:Soft Matter and Biological Physics,2004,15(1):53-60. doi: 10.1140/epje/i2004-10036-x
[20]	Neethling S J,Lee H T,Grassia P.The growth,drainage and breakdown of foams[J].Colloids and Surfaces A:Physicochem Eng Aspects,2005,263(3):184-196. doi: 10.1016/j.colsurfa.2004.12.014
[21]	Matzke E B.The three-dimension shape of bubbles in foam—an analysis of the role of surface forces in three-dimensional cell shape determination[J].Am J Botany,1946,33(1):281-289.
[22]	Brunke O,Odenbach S.In situ observation and numerical calculations of the evolution of metallic foams[J].J Phys:Condens Matter,2006,18(28):6493-6506. doi: 10.1088/0953-8984/18/28/005
[23]	Shen H,Oppenheimer S M,Dunand D C,et al.Numerical modeling of pore size and distribution in foamed titanium[J].Mechanics of Materials,2006,38(10),933-944.
[24]	黄晋，孙其诚.液态泡沫渗流的机理研究进展[J]，力学进展，2007,37(2):269-278.

施引文献

资源附件(0)

访问统计

点击查看大图

计量

文章访问数: 1109
HTML全文浏览量: 77
PDF下载量: 743
被引次数: 0

姓名
邮箱
手机号码
标题
留言内容
验证码

留言板

基于微观方法对液态铝泡沫宏观析液过程的数值模拟研究

doi: 10.3879/j.issn.1000-0887.2009.12.006

作者简介:
李科(1981- ),男,内蒙古鄂尔多斯人,副教授,博士(联系人.E-mail:like16615.student@sina.com);解茂昭(1944- ),男,成都人,教授,博士生导师(E-mail:xmz@dlut.edu.cn).

计量

Microscopical and Macroscopical Numerical Study on the Drainage Process in Fabricating Foamed Aluminum

计量

目录

留言板

基于微观方法对液态铝泡沫宏观析液过程的数值模拟研究

doi: 10.3879/j.issn.1000-0887.2009.12.006

作者简介: 李科(1981- ),男,内蒙古鄂尔多斯人,副教授,博士(联系人.E-mail:like16615.student@sina.com);解茂昭(1944- ),男,成都人,教授,博士生导师(E-mail:xmz@dlut.edu.cn).

计量

出版历程

Microscopical and Macroscopical Numerical Study on the Drainage Process in Fabricating Foamed Aluminum

计量

出版历程

目录

作者简介:
李科(1981- ),男,内蒙古鄂尔多斯人,副教授,博士(联系人.E-mail:like16615.student@sina.com);解茂昭(1944- ),男,成都人,教授,博士生导师(E-mail:xmz@dlut.edu.cn).